Looking fwd to the summer flying in Idaho and the back country air strips. 

From previous flights I have found that it would be better if I could "pack" five or so gallons of extra gas - I have the std 20 gallon setup.

I have seen pictures of tanks hanging on the wing struts - thought about a belly tank setup but then there IS the exhaust pipe.

Don't particularly want to put it inside the cabin with me or open the wings to add aux tanks - any and all ideas please.

Still grinning!!

Phil Smith

CH 70wonderful

Buhl, ID

Views: 672

Attachments:

Reply to This

Replies to This Discussion

When I got my 701 it had a 20litre steel tank up in the luggage compartment roof,it was professionally built ,when I did the rebuild I took it out not keen have fuel in the cabin with me .cheers Geoff
Hi Phil, The fuel pods that attach to the struts are very popular on ultralights.They can be easy to add on a CH701 and hooked up to your fuel system,they hold about 5 Gallons each and are Sold in pairs with all the mounting hardware and fittings. You can purchase from Leading Edge and WagAero (same Co.)in Wisconsin,CPS,LockWood,The cost is around $300.+shipping Tks Wayne

I am with Wayne. This is about as simple of a solution as one most likely will find. I added them to my Beaver ultralight to extend the range and it was a relatively easy system to plumb. When I added them, it did not seem to affect the cruise speed much on my 70 mph UL. Not real pretty but should be able make the tanks and hardware quickly removable fairly easily. Aircraft Spruce also has them: http://www.aircraftspruce.ca/catalog/eppages/ultralighttank05-12347...

Joe

I would want to do some research with the factory or a good engineer before hanging those on the struts of any airplane. The tank and brackets and such weigh five pounds and the five gallons of fuel another 30 pounds. That's 35 pounds at mid-span on the struts. I suspect that much weight on a very turbulent day or a very rough landing could induce some powerful forces, perhaps enough to bend or break the struts.

Also, I am presuming the picture above is not a US ultralight. US ultralights include in the definition of the class a fuel capacity limit of 5 gallons. An ultralight with 10 gallons of fuel on the wing struts would no longer be a legal machine.

You right this would not be considered a basic Ultralight in the USA. It would be considered LSA or have N registered. In Canada it would be Ultralight or Amateur Built.

I understand that you don't want to have fuel inside the cabin, but still want to make this proposal: Put a race fuel cell in the baggage area and pump fuel from there into one of the main tanks. They are even available with bladders inside and are capable of withstanding the most severe race car crashes.

 

We will go for such a setup. That way, I don't have to tinker with the original fuel system and can also make the tank easily removable, with fuel quick connectors, if desired. Another advantage is, that I will put the additional load in a place which is designed for it. Who knows how well the under-wing tanks and their attachment points will withstand operation in the ID backcountry!?   

 

Two common sources for fuel cells:

https://www.summitracing.com/int/search/part-type/fuel-cells?SortBy...

 

http://www.jegs.com/c/Fuel-Carbs-Intakes_Fuel-Cells-Fuel-Tanks/1029...

Have you thought of putting it behind the luggage compartment?  I have seen a few header tanks that mount in the fuselage behind the baggage area, thus out of the cockpit, not hanging on the wings causing more drag and out of the elements.  Just a thought.  Hope you are getting out flying.

Hey Phil,

Nice looking bird!

You bring up a valid point - here are a few things that you can consider:

You are flying an economical aircraft

In most of the Idaho back country strips you are never too far from fuel sources so fuel management is not a big problem

If you still want to opt for additional capacity, there are many certified aircraft out there that have fuel in baggage and/or nose bowl areas, so it is proven that living with fuel is not a big problem and should ease your concerns.

As mentioned in a earlier post on this blog, technology has greatly improved safety, i.e.race car fuel bladders, etc...

Contact the Heintz for their thoughts on modifications

A side note for all who are thinking about back country flying, be sure to get a personal checkout for each strip you desire to land on. 

These strips are known to bite the uninitiated!

Back country instructors are readily available.

Fly safe,

Mack Kreizenbeck

Meridian, Idaho

N990MK

I have two 5 gallon fuel bags I got a few years back through Alaskan Bushwheels...they don't make them anymore, just water bags.  Some googling came up with these Chinese bags that Cubcrafter pilots have had good luck with...they look just like my alaskan bushwheel bags, which are great, they don't leak and they take up no room when empty.  You do have to put together a spout for them, which I did with some basic plumbing supplies...you just lay the bag on the wing with the spout in the fill opening and open the valve. Here's a link to the Cubcrafters forum, a link to the bags and a link to a spout you can use:

http://forum.cubcrafters.com/showthread.php/2888-fuel-bag

http://www.tmart.com/Portable-20L-Soft-Folding-Oil-Sac-Gasoline-Buc...

http://www.airframesalaska.com/Backcountry-Liquid-Bag-Spout-with-Va...

Don,
All good stuff thanks for the links.
Phil

RSS

New from Zenith:

Zenith Planes For Sale 
 

Classified listing for buying or selling your Zenith building or flying related stuff...


Custom Instrument Panels
for your Zenith
:

Custom instrument panels are now available directly from Zenith Aircraft Company exclusively for Zenith builders and owners. Pre-cut panel, Dynon and Garmin avionics, and more.


Zenith Homecoming Tee:


Zenair Floats


Flying On Your Own Wings:
A Complete Guide to Understanding Light Airplane Design, by Chris Heintz


Builder & Pilot Supplies:

Aircraft Insurance:

 
 

West Coast USA:

 
Pro Builder Assistance:

 

Transition training:

Lavion Aero

K&S Aviation Services

Aircraft Spruce & Specialty for all your building and pilot supplies!

How to videos from HomebuiltHELP.com

Developed specifically for Zenith builders (by a builder) these videos on DVD are a great help in building your own kit plane by providing practical hands-on construction information. Visit HomebuiltHelp.com for the latest DVD titles.

© 2024   Created by Zenith.Aero.   Powered by

Badges  |  Report an Issue  |  Terms of Service