Q&A - Zodiac 601XL -650 for the latest upgrade drawings of November 24 2009

This Q&A is for the upgrade kit of the Zodiac 601XL & 650 based on drawings of Nov. 24, 2009 and AMD Safety Alert of November 7. 2009
http://www.newplane.com/amd_downloads/SAFETY%20ALERT%20November%207...

New drawings:
Nov. 24, 2009: We've updated the draft Drawings 6-ZU-1, 6-ZU-2, 6-ZU-3 and 6-ZU-4, and LAA Aileron Balance.

For very detailed questions (or if you must complain or vent), email me at newplane@gmail.com

Please post all your questions on the last page.

Views: 6320

Replies are closed for this discussion.

Replies to This Discussion

Larry,
We do not have any elevator upgrades at this time. The trim motor is very close to a rib so the skin does not flex very much.
Rivet gun question - Sounds like I will need to buy a rivet gun and accessories. Perhaps you can help me determine exactly what I'll need.
1.) Am I correct that a 3X gun is acceptable?
2.) Can the spar rivets be installed using a straight rivet set or will an offset be required?
3.) I've set smaller solid rivets in an EAA sheetmetal class but never the size used in the spar. Will a 2 lb straight bucking bar do the job or will I need something more exotic?

Thanks,
Tim
Tim,
Yes a 3X should be just fine for a solid rivet gun. Regarding the type of rivet set, please see what Zenith did on the upgrade posting on this site. For the bucking bar, you an start with what you have and see how it works out. I think that all the solid rivets have easy access.
I was curious why the LAA decided to put the mass balance on the outside edge instead of in the center. Is there any other reasons other than they wanted the hole in the rear spar to be as far outboard as possible? Do you have any insite into this?

Thanks,
Mike
Mike,
Installing the mass balance weight on the outside makes it possible to do the retrofit without opening up the aileron skin. Also, making a large hole at the rear spar tip is OK.
Mathieu,

I posted an NTSB document in the Open Forum with photos of the recent Agnos, AR accident which showed similar compression buckling, but also showed scoring on the top of the flap which would be consistent with the top of the flap rubbing against the rivets on the top of the rear spar. This combined with with an 11/17 statement you made on the previous Q&A regarding rear spar strength, "Also, if the flaps are not properly rigged, they could vibrate and stress that area. The German flutter expert is concerned about loose flaps in the up position" makes me wonder if it would not be prudent to consider some type of inboard flap stop. The attached photo is a simple solution. Someone thought it might be Chris' first 601XL.
Attachments:
Doug,
With the flaps in the up position, against the stop, the system works great. When we see some of the accident aircraft with no stops, that is a consern. If people are having problems rigging the flaps, we need to know.
Part 6-ZU-3-6 is called out on the two assembly drawings on page 6-ZU-3, but I can't find a detailed drawing of the part. What is it?

Dale
Dale I think this is an uncorrected note on Dwg 6-ZU-3 which came from the 24 Nov revision where the seat angles were -6 and are now -4.

On the current 3 Dec Dwg 6-ZU-3 the note ref 6-ZU-3-5 has not been revised to reflect the changed part and refers to stainless steel rivets AS5, are any stainless rivets now required in the changes now that the top of centre spar are bucked rivets?

Malcolm
Mathieu, Aileron Stops, just want to verify your statement "Your present aileron stops are fine", so the new version is optional?

Seat Pan stiffeners 6-ZU-3-6: Will it be possible to run the new stiffeners back to back with the existing spar access panel stiffeners?

Upright Doubler: I know that some don't like the looks, but it will take minimal effort to bevel the edge, round/shape the corners and it will blend in perfectly.
Jake,
Aileron stops have not changed at the aileron area. We are adding a stop at the torque tube on drawing 6-ZU-4. We are recommending both.
Hi Mathieu.
I have installed the 6zu4-1 aileron stop. I think I will install a thicker guage L angle to the front of 6B17-1. There is quite a lot of flexing of the L angle when the stop is contacted by the control tube. I think 40 thou angles would be better.

RSS

New from Zenith:

Zenith Planes For Sale 
 

Classified listing for buying or selling your Zenith building or flying related stuff...


Custom Instrument Panels
for your Zenith
:

Custom instrument panels are now available directly from Zenith Aircraft Company exclusively for Zenith builders and owners. Pre-cut panel, Dynon and Garmin avionics, and more.


Zenith Homecoming Tee:


Zenair Floats


Flying On Your Own Wings:
A Complete Guide to Understanding Light Airplane Design, by Chris Heintz


Builder & Pilot Supplies:

Aircraft Insurance:

 
 

West Coast USA:

 
Pro Builder Assistance:

 

Transition training:

Lavion Aero

K&S Aviation Services

Aircraft Spruce & Specialty for all your building and pilot supplies!

How to videos from HomebuiltHELP.com

Developed specifically for Zenith builders (by a builder) these videos on DVD are a great help in building your own kit plane by providing practical hands-on construction information. Visit HomebuiltHelp.com for the latest DVD titles.

© 2024   Created by Zenith.Aero.   Powered by

Badges  |  Report an Issue  |  Terms of Service